Generacメーカー005818-0の使用説明書/サービス説明書
ページ先へ移動 of 36
EcoGen 6kW Generator Owner's Manual L I S T E D C U S Model 005818-0.
Introduction .............................................. 1 Read This Manual Thoroughly ................................................1 Safety Rules ............................................. 1 Contents .........................................
1 INTRODUCTION Thank you for purchasing this compact, high per formance, air -cooled, engine-driven generator . It is designed to supply electrical power to operate an inver ter/batter y charger as a component in an off-grid power solution.
2 !"#$%& "'()(& !*+,-.& /01,!& 234(5#66%& 7(584(& 9:)"3669:;<& 8=(43"9:;& 84& )(4 >929:;& "'9)& (?#9=@(:"A&.
3 !" #$% &' () *&+ $,+ #- '. (- &+$/ )0 #$1 %, /2$. #3 4( .# 5$'" #$6 .& 7# $&*0 $#8 '# .*& +$ 9$ #+ #- '. (- &+ +:$ -) *04 -' (; #$ <&. '5 $ ) 6$ ' "# $ =# *# .
n Only qualified electricians or contractors should attempt such installations, which must comply strictly with applicable codes, stan- dards and regulations. 1.1 UNP ACKING/INSPECTION !" #$%& '()*+,-(./&+*%$"'001& -(2)$+#& #3$&+4(#$(#2& "4%& 5*6*.
5 1.4 THE GENERA TOR Figure 1.1 * 6kW , V -twin, GT -530 Engine (door removed) Air Filter External Oil Fill/Dipstick Control Panel Data Label Circuit Breaker Fuel Inlet (back) Fue l Regulator Composite Base Battery Compartment Oil Filter Exhaust Enclosure Engine Oil Dipstick Engine Oil Fill Figure 1.
!"#$ $ %&'($ )'*&+)','-./$ 0-1$ )'23,,'-10 .+3-/ This unit uses a LP vapor withdrawal system only . This type of system uses the vapors for med above the liquid fuel in the storage tank. Recommended fuels should have a Btu content of at least 2,520 Btus per cubic foot for LP gas.
7 !"#$%&&'$()' *"+$',()-)'#)-.+/)#',+&&' "0$'1)' %22)/$)3'0-' 01#$- */$)34' 5' +"/&*3+"6'/0"/)%&)34' *"3)-6-0*"3'0-' /0.
8 General Information Figure 1.4 + Installation Guidelines 18 inches Minimum Distance 36 inches 36 inches 36 inches 60 inches 60 inches Existing W all No windows or openings in the wall permitted within 5 feet from any point of the generator .
9 !"!#$ %& ' '()*$ )(+,-)(.(/'0 See the Specifications section for cor rect batter y size and rating. !"!!$ %& ' '()*$ -/0' &11& '-2/ Fill the batter y with the proper electrolyte fluid if necessar y and have the batter y fully charged before installing it.
10 ! "#! $%&#! '(#!%')*)'+! ,-.#&! $%,,*+! )$! '%&/#0! -11! 2/0! '(#!3456! 1%$#! )$! -8#0! 1&-7! '(#! 9#/: #&2'-&! ;-/&ap.
11 ACTIVA TION CHART CHOOSE LANGUAGE TROUBLESHOOTING !"#$%&'()*&+#,( -#*( .))/0(1*'#( 23( #453%%( 23(+*#"5*+( %&67 89&8*:( ; 5*##( <=><)( 23(#*%*42: ?@( 2A.
12 !"# $%&'# (&) *+,'# *%+*# ,'-.*# /01*+2&# ,3# (04-+*,51&# 6,*%# 5+**&) 7# (%+)2&)#)+*,'238# *.) '#9::# *%&# -06&)# 3.--17#*0# *%&# 2&'&)+*0) " ;"# 9'# *%&# 2&'&)+*0)# -+'&18# 3&*# *%&# <.
13 Operation Figure 3.1 + Generator Control P anel Escape MAIN FUSE AUT O OFF MANUAL 7.5 AMP Enter !"#$% &'()*% "#+,(% -"% #&% *.,% /,$,(0*#( 1% *.,% 2')"304% '$*,( &05,% +'33% 6,/'$% 0$% '$)*0330*'#$% 0))')*0$*7% 8.
14 !"#$%&$'( !)$*&+&)$, The following notes apply during cranking cycle. 1. Star ter motor will not engage within five (5) seconds of the engine shutting down. 2. The fuel output will not be energized with the star ter . 3. The star ter and magneto outputs will be energized together .
15 High Engine T emperature (Shutdown Alarm 7 Auto Reset) A 10 second delay on star t-up and one (1) second delay before shutdown. Auto reset when the condition clears and restar t the engine if a valid star t signal is still present. This switch>s contacts (Figure 3.
16 !"#$ %&'( !"#$ %&'$ ()*$ +,-#$ ./$ 0"#$ 1./02.3$ *(/#3$ *2.0#10-$ 0"#$ 45$ 1./02.3$ 1621,60$ (7(6/-0$ .8#23.(9$ :;67,2#-$ <&=$ (/9$ <&>?&$ !"6-$ +,-#$ 6-$ @62#9$ 6/$ -#26#-$ @60"$ 0"#$ A(00#2 B$ .
17 4.3.3 OIL & OIL FIL TER CHANGE PROCEDURE T o change the oil, proceed as follows: 1. Star t the engine by moving the AUTO/OFF/MANU AL switch to MANUAL and r un until it is thoroughly warmed up. Then shut OFF the engine by moving the switch to the OFF position.
18 4.6 BA T TERY MAINTENANCE !"#$ %&''#()$ *"+,-.$ %#$ /0*1#2'#.$ 1#($ '"#$ 34#(5/2#$ 42"#.,-#3$ *#26 '/+07$!"#$ 8+--+9/0:$ 1(+2#.,(#$ *"+,-.$%#$ 8+--+9#.$ 8+($ /0*1#2'/+0; <7$ =0*1#2'$ '"#$ %&''#( )$ 1+*'*$ &0.
19 !"#$% &'(&#% )(#'*'$)#% +,% )-* *#)./% "-(0% ."#% 1+&-.% 2'((% ,.30% +$% 1(')#% 4+."% ."#% '((#$% 4*#$)"% '$0% .+5".#$% ."#% *-)6#*% '* 7% 8'7% $3.9% :+5".
20 4.11.2 RETURN TO SERVICE ! "# $%&'$(# &)%# '(*&#&"# +%$ ,*-%# ./ &%$# +&"$.0%1#2$"-%%3# .+# /"44"5+6 78# 9 %$*/:# &).&# '&*4*&:# 2"5%$# *+# &'$(%3# "//# .
21 Maintenance 4.12 SERVICE SCHEDULE A T TENTION : It is recommended that all service work be performed by the nearest Dealer . SYSTEM/COMPONENT PROCEDURE FREQUENCY X = Action R = Replace as Necessar y * = Notif y Dealer if Repair is Needed.
22 T roubleshooting 5.1 TROUBLESHOOTING GUIDE Problem Cause Correction !"#$#%&'%#$ ('))$ %*+$ ,-.%/0$ 10$ 2 34#$ 5)*(%0$ 10$ $ 6*- -#,+$ 4"*- +$ ,'-,3'+$,*%7'+'*%8$ -#9).,#$ :0;<$ =34#$'%$ &#%#-.
23 Appendix 6.1 MENU SYSTEM NAVIGA TION T o get to the MENU, use the "Esc" key from any page. It may need to be pressed many times before getting to the menu page. The currently selected menu is displayed as a flashing word. Navigate to the menu required by using the +/- keys.
24 Appendix MAIN MENU RUN LOG ALARM LOG HISTOR Y STA TUS COMMAND ST ATE VERSIONS DISPLA Y GENERA TOR FREQUENCY ENGINE HOURS ENGINE RPM BA TTERY V OL T AGE DEBUG INPUTS OUTPUTS DISPLA YS EDIT CONTRAST LANGU AGE TIME/DA TE EXERCISE TIME/SPEED ESC Press the “ESCAPE” key to jump back up through the menu levels.
Generac ® Pow er Systems, Inc. 25 25 Drawing No. 0J1320-A Installation Diagram.
26 Generac ® P ower Systems, Inc. 26 Installation Diagram Drawing No. 0J1320-A.
Generac ® Pow er Systems, Inc. 27 27 Drawing No. 0J1320-A Installation Diagram.
28 Generac ® P ower Systems, Inc. 28 28 ENGINE CONTROLLER VOLTAGE REGULATOR (AVR) ENGINE START BATTERY CHARGER 12 VOLT ENGINE START BATTERY ALTERNATOR BATTERY CHARGER INVERTER TWO-WIRE START BATTERY .
29 Drawing No. 0J1323-C Oil Make-up System.
30 Notes.
31 Notes.
32 FOR GENERA TORS 10KW AND BELOW !"#"$%&' "()**)+,' -+,.$+&' /%$$%,.0' *. % ."(",. 0+1$'/%$$%,.0' $)23.*' %,#' +4&)2% .)+,* The United States Environmental Protection Agency (EP A) and Generac Power Systems, Inc.
33 EMISSION CONTROL SYSTEM WARRANTY !"#$$#%&'(%&)*%+' ,-$)."' /0**0&)-'1!( ,'20* *0&)-3' 4%*'.
Part No. 0J0984 Revision A (10/14/10) Printed in U .S.A. W arranty GENERAC POWER SYSTEMS LIMITED W ARRANTY FOR "ECO GEN AIR-COOLED A UTOMATIC ST ANDBY GENERA TORS" !"# $ %$ &' #( ") $ " *$ + ,# '' $ - .
デバイスGenerac 005818-0の購入後に(又は購入する前であっても)重要なポイントは、説明書をよく読むことです。その単純な理由はいくつかあります:
Generac 005818-0をまだ購入していないなら、この製品の基本情報を理解する良い機会です。まずは上にある説明書の最初のページをご覧ください。そこにはGenerac 005818-0の技術情報の概要が記載されているはずです。デバイスがあなたのニーズを満たすかどうかは、ここで確認しましょう。Generac 005818-0の取扱説明書の次のページをよく読むことにより、製品の全機能やその取り扱いに関する情報を知ることができます。Generac 005818-0で得られた情報は、きっとあなたの購入の決断を手助けしてくれることでしょう。
Generac 005818-0を既にお持ちだが、まだ読んでいない場合は、上記の理由によりそれを行うべきです。そうすることにより機能を適切に使用しているか、又はGenerac 005818-0の不適切な取り扱いによりその寿命を短くする危険を犯していないかどうかを知ることができます。
ですが、ユーザガイドが果たす重要な役割の一つは、Generac 005818-0に関する問題の解決を支援することです。そこにはほとんどの場合、トラブルシューティング、すなわちGenerac 005818-0デバイスで最もよく起こりうる故障・不良とそれらの対処法についてのアドバイスを見つけることができるはずです。たとえ問題を解決できなかった場合でも、説明書にはカスタマー・サービスセンター又は最寄りのサービスセンターへの問い合わせ先等、次の対処法についての指示があるはずです。